KEKOPLAST GmbH
An der Windmühle 8
01917 Kamenz
Tel.: 0 35 78/38 03-0
Fax: 0 35 78/38 03-30
info /// While reliable active locating of non-metallic tubes and pipes with the help of galvanic or inductive methods does not cause problems anymore with perfected products (such as KEKOPLAST® detectable tapes No. 06 and No. 04), the myriametric wave method still has its limitations. Especially the locating lengths of location equipment leave a lot to desired with most civil engineering companies. Usual detectable tapes hitherto are not suitable for myriametric wave methods because they are poorly equipped with bad conducted location wires. They can only be located with difficulties or depending on their position and the composition of the ground, not at all when conventional detecting equipment is used. The result is that the course of non-metallic lines can sometimes only be guessed or will remain completely undetected. Possible consequences according to civil works or important repair works are self-evident.

/// These problems are now a thing of the past because of the cooperation with the FH Hannover and KEKOPLAST company who has been developed the KEKOPLAST® detectable tape No. 06 with copper wires. These tapes can be applied for all established detection measuring methods because of one or two isolated copper wires for active locating and to proof if the connection is inactive for the whole installed pipe as well as one blank copper wire for myriametric wave methods. The perforation above the blank copper wire assures optimal earth contact whereas the tape has otherwise a full transparent lamination.

/// The clear superior conductivity of copper (approximately 10 times) causes sensational locating results according to myriametric waves even over extreme short and long measuring distances. KEKOPLAST® detectable tapes No. 06 Cu achieve ex-cellent results even under difficult conditions such as poor wave accessibility because of geographical reasons, unfavourable line direction for location purposes, location tapes much deeper than 60 cm below the surface, unfavourable ground conditions, short lines of less than 20 m as well as nearby metal lines or pipes.

No. 6 Cu 1+1 Detectable Tape with copper wires

  • with copper wires according to DIN 54841-3
  • co-extruded polyethylene soft foil with one isolated and one blank copper wire, resistant to ageing and temperatures, colourfast, permanently legible, print is sealed with film lamination, free of PVC,
  • copper wires are prepared by KEKOPLAST® for connecting the ends of the rolls
  • standard colours: yellow, green, blue, red (other colours and dimensions upon request)
 

Packaging

Article-No.
Thickn.
Width
Length
Box
Pallet

0601500500250 CU1+1

0,15 mm
50 mm

250 m

4

50-90

0601501000250 CU1+1

0,15 mm

100 mm

250 m

2

30-50

Nr06_CU_1_1

Read more: No. 6 Cu 1+1 Detectable Tape with copper wires

No. 6 Cu 2+1 Detectable Tape with copper wires

  • with copper wires according to DIN 54841-3
  • co-extruded polyethylene soft foil with two isolated and one blank copper wire, resistant to ageing and temperatures, colourfast, permanently legible, print is sealed with film lamination, free of PVC,
  • copper wires are prepared by KEKOPLAST® for connecting the ends of the rolls
  • standard colours: yellow, green, blue, red (other colours and dimensions upon request)
       

Packaging

Article-No.

Thickn.

Width
Length
Box
Pallet

0601500500250 CU 2+1

0,15 mm
50 mm

250 m

4

50-90

0601500800250 CU 2+1

0,15 mm

50 mm

250 m

2

30-50

0601501000250 CU 2+1

0,15 mm

50 mm

250 m

2

30-50

0601502000250 CU 2+1

0,15 mm

50 mm

250 m

1

25

matrix_CU_2_1

 

Read more: No. 6 Cu 2+1 Detectable Tape with copper wires

No. 6 Detectable Tape with steel wires

  • with two stainless steel wires
  • co-extruded foil, polyethylene, with two stainless steel wires, earth contacted non-corrosive, resistant to ageing and temperatures, colourfast, permanently legible, print is sealed with film lamination, free of PVC
  • standard colours: yellow, green, blue, red (other colours and dimensions upon request)

 

       

Packaging

Article-No.

Thickn.

Width
Length
Box
Pallet

0601500400250

0,15 mm
40 mm

250 m

4

50-125

0601500800250

0,15 mm

80 mm

250 m

2

40-60

0601501000250

0,15 mm

100 mm

250 m

2

30-50

0601502000250

0,15 mm

200 mm

250 m

1

25

Nr06_edelstahl

Read more: No. 6 Detectable Tape with steel wires

info/// Despite of perfected products reliable locating of non-metallic, buried pipe lines, plastic tubes and ductile cast iron pipes is still problematic. Especially in the field of house service connection of public distribution networks detailed place names are missing. If, for instance, bench marks in position plans change, pipes will disappear without a trace. In case of underground construction works, non- identified pipe line systems are damaged regularly. As a result, the construction progress will be delayed and the cost spiral goes round.

/// KEKOPLAST® detectable tape No. 06 that is absolutely environment-neutral consisting of a polyethylene tape with 2 sinusoidal shaped, noncorrosive stainless steel wires and a diameter of 0,5 mm. The detectable tape is grounded by continuous slits in the laminated foil.

/// KEKOPLAST detectable tape No. 04 is made of polyethylene that has a non-corrosive, stainless steel band with a thickness of 0,1 mm and a width of 10 mm. The band is fixed on the bottom side. The perfect earthing is guaranteed through continuous earth contact of the stainless steel band.

No. 4 Detectable Tape with steel band

  • with stainless steel band
  • co-extruded foil, soft polyethylene, with stainless steel band, non-corrosive, resistant to ageing and temperatures, colourfast, permanently legible, print is sealed with film lamination, on a plastic coil
  • colours: yellow, blue, green, red (other colours and dimensions upon request)
 
Packaging
Article-No.
Thickn.
Width
Length
Box
Pallet

0601500400250

0,15 mm
40 mm

250 m

4

50-125
nr4

 

Read more: No. 4 Detectable Tape with steel band

Connecting Technic for Detectable Tapes

Article-No..                                  description  
610  Crimping Tool for Detectable Tape No. 04  Quetschzange_f_r_493051b50466b_60x60.png
620
Crimping Tool for Detectable Tape No. 06
Foto Nr 0003
611 
Crimp Connectors for Detectable Tape No. 06 and No. 06 cu
100 pieces per bag
Quetschverbindun_4930526723ea1_60x60.png
411
Crimp Connectors for Detectable Tape No. 04
200 pieces per bag
 P1040591
622
Shrink-down Plastic Tubes for Detectable Tape No. 06 Cu
50 pieces per bag
Schrumpfschlauch_493050bc60cd0_60x60.png
© 2018 by PL-Concepts